The short version of sublimation fits in a sentence. The long version — which is the one that helps — is below.
Reviewed 2026-06-12. Anything still debated is marked as such rather than presented as settled.
Quality control for lyophilized materials includes visual inspection, residual moisture measurement, and reconstitution testing. Cake appearance can reveal process problems such as collapse, shrinkage, or meltback, although appearance alone does not prove potency. Residual moisture is commonly measured by Karl Fischer titration or by loss on drying. Reconstitution time is checked because a slow or incomplete dissolve can indicate a change in pore structure. Stability studies track these attributes over time under defined temperature and humidity conditions.
Analytical methods for lyophilized solids must account for the low moisture content and the fragile cake. Karl Fischer titration is widely used for water content, while near-infrared spectroscopy can measure moisture non-destructively in sealed containers. X-ray diffraction and modulated differential scanning calorimetry help identify crystalline or amorphous phases. Residual solvent analysis may be needed if organic solvents were used during formulation. The combination of these methods supports batch release and long-term stability assessment.
A freeze-dryer consists of a vacuum chamber, temperature-controlled shelves, a condenser, and a vacuum pump. Vials, ampoules, or bulk trays hold the product during the cycle. The condenser traps water vapor as ice at a temperature lower than the product. Cycle development balances shelf temperature, chamber pressure, and time. Scale-up can be difficult because heat and mass transfer change with equipment size, so process analytical tools and conservative validation are often used.
Lyophilization is a dehydration technique in which a product is frozen and the solvent is removed under reduced pressure. The low pressure allows ice to sublimate directly into vapor without passing through a bulk liquid phase. This differs from conventional drying, where heat drives evaporation and can damage heat-sensitive structures. The process is used for biological materials, pharmaceutical formulations, and some foods. Its main advantage is preservation of porous structure and rapid reconstitution.
| Property | Value | Notes |
|---|---|---|
| Storage temperature | 2–8 °C or 20–25 °C | Depends on product stability; some require frozen storage. |
| Moisture content | 0.5–3% w/w | Higher values may reduce stability; target set per product. |
| Moisture method | Karl Fischer titration | Coulometric for low levels; volumetric for higher levels. |
| Cake appearance | Uniform, intact, no collapse | Visual inspection is qualitative and not a potency measure. |
| Reconstitution time | Seconds to several minutes | Depends on cake density, excipients, and diluent. |
Handling practices aim to prevent moisture ingress and mechanical damage. Vials should remain stoppered and crimped until use, and reconstitution should follow the labeled diluent and volume. Shipping may involve temperature-controlled containers and desiccants, but direct contact between desiccant and product is avoided. Regulatory guidance expects documented storage conditions, excursion assessments, and stability commitments. Open questions remain about how best to predict long-term stability from short accelerated studies for every formulation class.
After lyophilization, the product is usually a porous cake or powder with a large internal surface area. This structure can absorb moisture quickly if exposed to humid air, so vials are sealed under vacuum or an inert gas. Moisture uptake may lower the glass transition temperature of the dried matrix and accelerate chemical or physical degradation. Storage conditions therefore depend on the formulation, container, and intended shelf life. Some products remain stable at room temperature, while others require refrigeration or freezing.
Freeze-drying is used for materials whose activity or structure depends on low temperature and low water content. Examples include certain biologics, diagnostic reagents, starter cultures, coffee, and porous inorganic precursors. The dried product forms a cake whose porosity aids rapid wetting and dissolution. Main drawbacks are high energy use, long cycle times, and sensitivity to formulation and equipment variation. Questions remain about how freezing rates and ice morphology affect batch uniformity, especially when moving from laboratory to production scale.
Lyophilization, also called freeze-drying, is a dehydration process in which a solvent, usually water, is frozen and then removed by sublimation under reduced pressure. The method preserves heat-sensitive materials that would degrade in conventional drying. Large-scale use grew during the mid-twentieth century for blood plasma and antibiotics, and it later expanded to vaccines, enzymes, foods, and advanced materials. The process produces a dry, porous solid that usually reconstitutes rapidly. It is distinct from simple evaporation because the solvent bypasses the liquid phase during primary removal.
The process generally proceeds in three stages: freezing, primary drying, and secondary drying. During freezing, controlled cooling converts water into ice and may also crystallize or vitrify solutes. In primary drying, the pressure is lowered below the triple point, and heat is supplied so ice sublimes directly to vapor. Secondary drying removes water that remains bound to the solid matrix, yielding a low final water content. Product temperature must stay below the collapse or glass transition temperature to maintain structure. Cycle design therefore balances shelf temperature, chamber pressure, and time.
Storage conditions depend on the formulation and the intended shelf life. Many pharmaceutical and biological freeze-dried products are kept at 2–8 °C, while some stable foods and reagents tolerate room temperature. Others require −20 °C or colder to slow chemical degradation or aggregation. Protection from light and oxygen is common because oxidation can continue in the dry state. Stability studies usually monitor potency, appearance, moisture, and reconstitution time over months or years. Predictions from accelerated studies are useful but may not fully capture real-time changes.
Quality control for freeze-dried lots combines visual inspection with instrumental tests. Cake appearance, color, and shrinkage are recorded against a reference, while residual moisture is measured by Karl Fischer titration or loss on drying. Thermal analysis can reveal phase transitions and crystallization events, and X-ray diffraction distinguishes amorphous from crystalline solids. Microbiological tests and container closure integrity checks are also routine for sterile products. Analytical methods must be validated for the matrix, because excipients and low moisture can affect accuracy. Open questions include how best to predict long-term stability from short-term data.
Lyophilized solids are often hygroscopic, so handling occurs in controlled low-humidity areas or glove boxes when the material is exposed. Vials remain sealed with elastomeric stoppers and aluminum crimps until use, because airborne moisture can raise residual water and shorten shelf life. The porous cake is fragile and may crack, shrink, or powder during transport. Personnel typically avoid repeated warming and cooling of sealed units, which can draw moisture through closures. These practices aim to preserve the low water content achieved during drying.
This is a list of biochemists. It should include those who have been important to the development or practice of biochemistry. Their research or applications have made significant contributions in the area of basic or applied biochemistry.
The light-nanosecond is defined as exactly 29.9792458 cm. It was popularized in information technology as a unit of distance by Grace Hopper as the distance which a photon could travel in one billionth of a second (roughly 30 cm or one foot): "The speed of light is one foot per nanosecond."
Research on PFOA has demonstrated ubiquity, animal-based toxicity, and some associations with human health parameters and potential health effects. Additionally, advances in analytical chemistry in recent years have allowed the routine detection of low- and sub-parts per billion levels of PFOA in a variety of substances. In 2013, Gore-Tex eliminated the use of PFOAs in the manufacture of its weatherproof functional fabrics. Major companies producing PFOA signed with the Global PFOA Stewardship Program with the goal of elimination of PFOA by 2015. Since then it has been eliminated from the production of non-stick materials used in cookware. GenX has been introduced as a replacement for PFOA, but in a 2015 study which tested the effects on rats, GenX caused many of the same health problems as PFOA, but required much higher concentrations. This is because GenX (C3) is a short chain alternative to PFOA. GenX also has a significantly shorter half-life than PFOA so it is not as bio-persistent as PFOA or other long chain perfluorinated chemicals.
Anthropology & Education Quarterly. 13 (2): 133–148. doi:10.1525/aeq.1982.13.2.05x1830j. JSTOR 3216627. Spain, Victor; Scarlett, Janet; Houpt, Katherine (2004). "Long-term Risks and Benefits of Early-age Gonadectomy in Cats". Journal of the American Veterinary Medical Association. 224 (3): 372–379. doi:10.2460/javma.2004.224.372. PMID 14765796. Sturgess, Kit; Hurley, Karyl (2005). "Nutrition and Welfare". The Welfare of Cats. Animal Welfare. Vol. 3. Rochlitz. pp. 227–257. doi:10.1007/1-4020-3227-7_9. ISBN 1-4020-3226-9. Sunquist, Fiona; Sunquist, Mel (2014). The Wild Cat Book: Everything You Ever Wanted to Know About Cats. Chicago University. ISBN 978-0-226-14576-1. Tootle, John; Friedlander, Michael (1989). "Postnatal Development of the Spatial Contrast Sensitivity of X- and Y-cells in the Kittens Retinogeniculate Pathway". The Journal of Neuroscience. 9 (4). Journal of Neuroscience: 1325–1340. doi:10.1523/JNEUROSCI.09-04-01325.1989. PMC 6569875. PMID 2703879. Tsutsui, Toshihiko; Stabenfeldt, George (1993). "Biology of Ovarian Cycles, Pregnancy and Pseudo Pregnancy in the Domestic Cat". Journal of Reproduction and Fertility Supplement. 47: 29–35. PMID 8229938. Vandivert, Rita (1975). Understanding Animals as Pets. Illustrated Publishing. ISBN 978-0-7232-6118-6. Walls, Jerry (1991). Kittens as a New Pet. TFH Publications. ISBN 978-0-86622-614-1. Greco, D.S. (2014). Pediatric Nutrition. Veterinary Clinics of North America: Small Animal Practice. ISBN 978-0-32337-185-8.{{cite book}}: CS1 maint: publisher location (link)
=== Other Heseltine comments === Heseltine criticised the Coalition's policy on Europe, but he did support the tightening of immigration laws. He also supported George Osborne's Budget measures in 2013 and Iain Duncan Smith's welfare reforms, but showed concerns over the legalisation of same-sex marriage. In June 2013, he voted against Lord Dear's wrecking amendment, thus ratifying the same-sex marriage act.
Sources: en.wikipedia.org
=== Al–Am === Bruce Alberts (b. 1938). American biochemist at UC San Francisco, known for his work on protein complexes that enable chromosome replication in science, public policy, and as an original author of the textbook Molecular Biology of the Cell. Member Natl. Acad. Sci. USA. Robert Alberty (1921–2014). American physical biochemist at MIT, noted for many contributions to enzyme kinetics, including early studies of reactions with two substrates. Member Natl. Acad. Sci. USA. Dario Alessi (b. 1967). British biochemist at the University of Dundee known for work on protein kinases. Mary Belle Allen (1922–1973). American botanist at UC Berkeley known for demonstrating the role of chloroplasts in photosynthesis. Jorge Allende (b. 1934). Chilean biochemist at the University of Chile, known for contributions to the understanding of protein biosynthesis and how transfer RNA is generated. Member Natl. Acad. Sci. USA. C. David Allis (1951–2023), US biologist at the Rockefeller University who worked on chromatin. Richard Amasino (b. 1956). American Professor of Biochemistry and Genetics at the University of Wisconsin–Madison, who studies vernalization. Member Natl. Acad. Sci. USA. Bruce Ames (1928–2024). Biochemist and microbiologist at UC Berkeley. He is an expert on mutagenicity and an inventor of the Ames test. Awarded the National Medal of Science John E. Amoore (1939–1998). British biochemist and zoologist at UC Berkeley, who postulated the stereochemical theory of olfaction.
The twenty-foot equivalent unit is the volume of the smallest standard shipping container. It is equivalent to 1,172 cubic feet (33.2 m3). Larger intermodal containers are commonly described in multiples of TEU, as are container ship capacities.
An arterial embolism is caused by one or more emboli getting stuck in an artery and blocking blood flow, causing ischemia, possibly resulting in infarction with tissue death (necrosis). Individuals with arterial thrombosis or embolism often develop collateral circulation to compensate for the loss of arterial flow. However, it takes time for sufficient collateral circulation to develop, making affected areas more vulnerable for sudden occlusion by embolisation than for e.g. gradual occlusion as in atherosclerosis.
In 1960, the SAC Airborne Command Post or "Looking Glass" was initiated, with the conversion of 5 (6 but 1 was reverted ) KC-135A tankers to Airborne Command Posts. In July 1960, operational testing began under the code name Looking Glass, with a SAC general officer always aboard each flight, and operated by the 34th Air Refueling Squadron at Offutt AFB. In August 1966, the mission transferred to the 38th Strategic Reconnaissance Squadron, to the 2nd Airborne Command and Control Squadron in April 1970, to the 7th Airborne Command and Control Squadron in July 1994, and to the USSTRATCOM's Strategic Communications Wing One in October 1998. In February 1961, the Strategic Air Command put Looking Glass mission on continuous airborne alert. Aircraft from the 34th Air Refueling Squadron were based at its headquarters at Offutt AFB, backed up by aircraft flying with the Second Air Force / 913th Air Refueling Squadron at Barksdale AFB, Louisiana, the Eighth Air Force / 99th Air Refueling Squadron at Westover AFB, Massachusetts, and the Fifteenth Air Force / 22d Air Refueling Squadron, March AFB, California. EC-135 Looking Glass aircraft were airborne 24 hours a day for over 29 years, until July 24, 1990, when "The Glass" ceased continuous airborne alert, but remained on ground or airborne alert 24 hours a day. The Looking Glass mission mirrors ground-based command, control, and communications (C3 or C³) located at the USSTRATCOM Global Operations Center (GOC) at Offutt AFB.
== Mechanism of action == Ionophores are chemical compounds that reversibly bind and transport ions through biological membranes in the absence of a protein pore. This can disrupt the membrane potential, and thus these substances could exhibit cytotoxic properties. Ionophores modify the permeability of biological membranes toward certain ions to which they show affinity and selectivity. Many ionophores are lipid-soluble and transport ions across hydrophobic membranes, such as lipid bilayers found in the living cells or synthetic vesicles (liposomes), or liquid polymeric membranes (carrier-based ion selective electrodes). Structurally, an ionophore contains a hydrophilic center and a hydrophobic portion that interacts with the membrane. Ions are bound to the hydrophilic center and form an ionophore-ion complex. The structure of the ionophore-ion complex has been verified by X-ray crystallography.
Sources: en.wikipedia.org
=== Europe === Germany: German Chancellor Olaf Scholz said that "Any resettlement plans, the idea that the citizens of Gaza will be expelled from there to Egypt or Jordan, is unacceptable." Russia: Russia's foreign ministry said that Trump's remarks were "shocking" and would add to tensions in the region. A Kremlin spokesperson said that the Kremlin was waiting for more details on the plan.
=== Folk remedies === Leaves of Heliotropium foertherianum (Boraginaceae) – also known as octopus bush – are used in many Pacific islands as a traditional medicine to treat ciguatera fish poisoning. Octopus bush leaves contain rosmarinic acid and derivatives, which are known for their antiviral, antibacterial, antioxidant, and anti-inflammatory properties. An account of ciguatera poisoning from a linguistics researcher living on Malakula island, Vanuatu, indicates the local treatment: "We had to go with what local people told us: avoid salt and any seafood. Eat sugary foods. And they gave us a tea made from the roots of ferns growing on tree trunks. I don't know if any of that helped, but after a few weeks, the symptoms faded away". Various Caribbean folk and ritualistic treatments originated in Cuba and nearby islands. The most common old-time remedy involves bed rest subsequent to a guanabana juice enema. In Puerto Rico, natives drink a tea made from mangrove buttons, purportedly high in B vitamins, to flush the toxic symptoms from the system. There has never been a funded study of these treatments. Other folk treatments range from directly porting and bleeding the gastrointestinal tract to "cleansing" the diseased with a dove during a Santería ritual.
== Mutation screening == DHPLC is widely used as a high-throughput mutation-screening method in both research and diagnostic applications, but samples with altered chromatographic patterns generally still require follow-up DNA sequencing to identify the exact variant. Early reports highlighted automated instrumentation, analyses of about 5 minutes per sample, and the ability to analyze PCR fragments up to 1.5 kb.
Amylin, or islet amyloid polypeptide (IAPP), is a 37-residue peptide hormone. It is co-secreted with insulin from the pancreatic β-cells in the ratio of approximately 100:1 (insulin:amylin). Amylin plays a role in glycemic regulation by slowing gastric emptying and promoting satiety, thereby preventing spikes in blood glucose levels after a meal. IAPP is processed from an 89-residue coding sequence. Proislet amyloid polypeptide (proIAPP, proamylin, proislet protein) is produced in the pancreatic beta cells (β-cells) as a 67 amino acid, 7404 Dalton pro-peptide and undergoes post-translational modifications including protease cleavage to produce amylin.
== History == Crisaborole was developed by Anacor Pharmaceuticals for the topical treatment of psoriasis. During preclinical and clinical development, crisaborole was called AN2728 and PF-06930164. The drug was assumed to be potential $2bn-a-year blockbuster, when Pfizer acquired Anacor Pharmaceuticals. However, the drug was commercially not successful, reaching only US$147 million in sales in 2018, and US$138 million in sales in 2019. Crisaborole was approved for use in the United States in December 2016 and for use in Canada in June 2018. The safety and efficacy of crisaborole were established in two placebo-controlled trials with a total of 1,522 participants ranging in age from two years of age to 79 years of age, with mild to moderate atopic dermatitis. In both trials participants received treatment with either crisaborole or placebo twice daily for 28 days. Neither the participants nor the health care providers knew which treatment was being given until after the trials were completed. Overall, participants receiving crisaborole achieved greater response with clear or almost clear skin after 28 days of treatment. The trials were conducted in the US. Crisaborole, approved for the treatment of mild to moderate atopic dermatitis in the European Union, has been rapidly withdrawn from the European market (March 2020 - February 2022).
Sources: en.wikipedia.org
Most lyophilized products are stored in sealed containers at controlled temperature and humidity. Some require refrigeration, while others are stable at room temperature. Protection from light and moisture is often necessary.
Cake collapse indicates that the porous structure was lost during drying. It can result from excessive product temperature or an unsuitable formulation. Collapsed cakes may have slower reconstitution and are often rejected by visual inspection.
Residual moisture affects the chemical and physical stability of a lyophilized solid. High moisture can promote degradation, aggregation, or cake shrinkage. The acceptable range is set for each product based on stability data.
Yes, the terms are generally interchangeable. Lyophilization is more common in pharmaceutical and laboratory contexts, while freeze-drying appears widely in food science and general writing. Both describe removal of solvent by sublimation under vacuum after freezing.